Skip to main content
  • Original research article
  • Open access
  • Published:

Emergency department impaired adherence to personal protective equipment donning and doffing protocols during the COVID-19 pandemic

Abstract

Objectives

Coronavirus Disease 2019 (COVID-19) is a highly infectious viral pandemic that has claimed the lives of millions. Personal protective equipment (PPE) may reduce the risk of transmission for health care workers (HCWs), especially in the emergency setting. This study aimed to compare the adherence to PPE donning and doffing protocols in the Emergency Department (ED) vs designated COVID-19 wards and score adherence according to the steps in our protocol.

Design

Prior to managing COVID-19 patients, mandatory PPE training was undertaken for all HCWs. HCWs were observed donning or doffing COVID-19 restricted areas.

Setting

Donning and doffing was observed in COVID-19 designated Emergency department and compared to COVID-19 positive wards.

Participants

All HCWs working in the aforementioned wards during the time of observation.

Results

We observed 107 donning and doffing procedures (30 were observed in the ED). 50% HCWs observed donned PPE correctly and 37% doffed correctly. The ED had a significantly lower mean donning score (ED: 78%, Internal: 95% ICU: 96%, p < 0.001); and a significantly lower mean doffing score (ED: 72%, Internal: 85% ICU: 91%, p = 0.02).

Conclusions

As hypothesized, HCWs assigned to the designated ED wing made more protocol deviations compared with HCWs positive COVID-19 wards. Time management, acuity, lack of personnel, stress and known COVID-19 status may explain the lesser adherence to donning and doffing protocols. Further studies to assess the correlation between protocol deviations in use of PPE and morbidity as well as improvement implementations are required. Resources should be invested to ensure PPE is properly used.

Introduction

Personal protective equipment (PPE) is defined as barrier clothing, gloves, eye protection and/or headgear designed to protect from a potential hazardous exposure. In medicine, these exposures are typically either infectious diseases or toxins (1). The transmission of the Severe acute respiratory syndrome coronavirus 2 (SARS-CoV-2), and its disease, COVID-19, is presumed to be primarily through droplets and fomites, although viral particles have also been found in feces of seropositive patients. A recent study by Van Doremalen et al. suggested aerosol and fomite as a mode of SARS-CoV-2 transmission, and reinforced the reported high spread rate (2). In hospital settings, performing aerosol-generating procedures (e.g. intubation, suction, bronchoscopy and cardiopulmonary resuscitation) facilitated patient-to-healthcare worker (HCW) transmission (3, 4).

The COVID-19 pandemic has highlighted the need for appropriate PPE to reduce transmission risks for HCWs caring for COVID-19 patients (5). Reports from Italy’s experience dealing with COVID-19 suggest that up to 20% of healthcare professionals dealing with COVID-19 patients became infected with the virus, with some reported deaths (6). China’s experience also found 41% of patients in one hospital acquired COVID-19 in hospital (7). Furthermore, Adams et al. reported that 3000 HCWs were infected with COVID-19 and 22 died (8).

International guidelines exist for HCWs regarding PPE use to minimize COVID-19 transmission (9, 10), and precautions during donning and doffing are recommended in all guidelines (4).

PPE donning and doffing entails specific steps, reportedly taking 7 to 15 min for donning and 14 to 23 for doffing (11).

A review of the literature between 2014 to 2020 reported HCW protocol deviations both during donning and doffing when using PPE, with consequential contamination risks (5, 12,13,14,15).

To the best of our knowledge, in-situ PPE donning and doffing has not been studied in designated COVID-19 wards. Our objective was to assess adherence of PPE donning and doffing protocols, and compare Emergency Department (ED) assessments to non-emergency departments. Due to the suspected status of the patients, high volume of patients with variable degrees of acuity and inappropriate staff to patient ratios, we hypothesized that protocol deviations would be more likely to occur in COVID-19 ED wing and less likely in COVID-19 confirmed floors (i.e. Intensive Care Unit - ICU and internal medicine ward).

Methods

Study design

This study comprised three groups; teams entering and exiting the COVID-19 suspected ED wing, COVID-19 confirmed ICU and COVID-19 internal medicine ward.

Study protocol

A checklist was created, based on the hospital protocol for donning and doffing PPE (Appendices 1a and 1b). This protocol is based on the guidelines of the World Health Organization (WHO) and the Centers for Disease Control and Prevention (CDC) regarding PPE for COVID-19 (9, 10). Donning was assessed in eleven steps, and doffing in eight steps with an extra step for those wearing eyeglasses. Mandatory PPE donning and doffing training was undertaken for all HCWs between March 4 and April 10, 2020. Prior to managing COVID-19 suspected/positive patients, all HCWs participated in a group, frontal demonstration and practice. A short video clip was distributed to all hospital staff. A poster (Additional file 1) was placed in all departments, and the poster and video were available via the hospital COVID-19 mobile app.

Observers were trained by the epidemiology department to teach and observe donning and doffing. Observations were conducted between April 20th and April 26th, 2020. Time slots for observations were chosen randomly but included all hours of the day, all days of the week. The HCWs were not alerted to observations taking place to reduce possible procedural bias however, all wards had PPE adherence staff in place during the time of the observations.

A sample donning and doffing event was calculated by all members of the team to assess intra-team validity. Donning and doffing was scored according to the correct performance of each item thus the maximum score for donning was 11 and for doffing was 8 (9 if wearing eyeglasses). We used a detailed checklist to minimize intra-observer variation.

Our Institutional Review Board waived the need for approval and consent due to the nature of the project.

Study setting, population and sample size

This study was performed in a-1100 bed, tertiary care center between March 4 and April 26, 2020 as part of a quality improvement project during the COVID-19 pandemic.

Observations of 107 HCWs were performed in COVID-19 designated departments - internal medicine ward (Internal; 62 HCWs) and intensive care unit (ICU) for confirmed positive COVID-19 cases (15 HCWs) and a designated emergency department (ED) wing for suspected or confirmed COVID-19 cases (30 HCWs). All three departments had designated areas for both donning and doffing. Observations were recorded according to the checklist (Appendices 1a and 1b).

Inclusion criteria: HCWs assigned to COVID-19 designated wards and ED, entering or exiting the restricted area when observers were present.

Data analysis

All checklist records were collected via Microsoft Excel 2016 (version 16.0.4266.1001). Mean donning and doffing score were our primary outcome. Generalized Linear Models (GLM) were calculated and analyzed with R software (version 3.6.1) to predict PPE donning and doffing mean score based on department type, worker type and their interaction.

Results

One hundred and seven HCW observations were made; 56 during donning and 51 during doffing out of which, 19 and 11 HCWs in the ED respectively. HCWs included: nurses (n = 50), attending physicians (n = 4), resident doctors (n = 11), intern doctors (n = 7), physiotherapists (n = 3), janitors (n = 4), patient transport staff (n = 16), X-Ray technicians (n = 7), paramedics (n = 1), and administrative staff (n = 2), in three different departments: COVID-19 positive internal medicine department (Internal; n = 62), suspected COVID-19 designated Emergency Department (ED; n = 30), and the COVID-19 positive Intensive care unit (ICU; n = 15).

Additional file 1 presents the PPE steps for donning. 50% donned their PPE without protocol deviations (16% entering the ED, 57% HCWs entering the ICU and 70% entering the internal medicine ward). Major omissions included failure to remove ID badges, jewelry and cell phones; failure to disinfect hands in at least one of the required steps, and neglecting to don gloves over cuffs. Figure 1A refers to donning by step. During donning, 41% HCWs failed to use hand sanitizer in at least one step. 32% of HCWs in the ED, failed to don gloves properly.

Fig. 1
figure 1

a. Percent of donning steps properly done by step. b. Percent of doffing steps properly done by step

We used a Generalized Linear Model (GLM) with quasibinomial distribution and a logit link function to predict donning mean score based on department type and worker type. We found that the emergency department had a significantly lower mean donning score (ED: 78%, Internal: 95% ICU: 96%, β = − 1.2, SE = 0.29, p < 0.001). Figure 2A shows the donning score by department. No differences were found between worker types.

Fig. 2
figure 2

a. Mean donning score by department. Individual points (light blue) indicate individual scores; large points (dark blue) indicate mean score; error bars indicate confidence intervals; b. Mean doffing score by department. Individual points (light blue) indicate individual scores; large points (dark blue) indicate mean score; error bars indicate confidence intervals

Overall, 37% doffed their PPEs appropriately. Figure 1B refers to doffing by step. Gaps were observed in all steps; HCWs neglected to remove gloves, visor, cap, gown and N95 mask properly and failed to disinfect hands in at least one of the 3 steps. While doffing, 12% of all HCWs observed failed to disinfect their hands in at least one of 3 of the steps (steps 2, 6 and 8). Most cases of failure to disinfect hands in one of the 3 steps took place in the ED (73%). Of the 11 HCWs wearing glasses, 5 (45%) appropriately doffed by having someone else remove the glasses before removing the N-95 mask. 78% of all observed HCWs removed the N95 respirator mask appropriately.

We used a Generalized Linear Model (GLM) with quasibinomial distribution and a logit link function to predict donning mean score based on department type and worker type. The emergency department had a significantly lower mean doffing score (ED: 72%, Internal: 85% ICU: 91%, β = − 0.82, SE = 0.35, p = 0.02). Figure 2B shows the doffing score in the different departments. No differences were found between the worker types.

Discussion

In our observational study of donning and doffing steps in COVID-19 departments, we report the overall rate for fully correct donning and doffing to be 44%.

This concerning finding is similar to prior studies observing PPE use (5, 11, 16, 17). Kwon at al reported that protocol deviations were common in both donning and doffing, and found that 100% of Ebola Virus Disease HCWs committed at least one PPE protocol deviation during doffing and 27% while donning (5). Casalino et al. reported that PPE doffing protocol deviations occurred even after a three-phase training program (11).

During the SARS-CoV-2 pandemic, and specifically within the time period in which our study took place, strategies to improve adherence had not yet been implemented. Failure to improve the success rate may have a profound effect on HCWs morbidity. Protocol deviations in donning and doffing may have multifactorial causes. Gaps between the development of Infection Protection and Control guidelines, their introduction to the target audience, and their implementation (4, 18), likely occur for a number of reasons. Firstly, HCWs may lack sufficient practice and simulation time (11, 18); a review by Houghton et al. (2020) have suggested support from managers, workplace culture, physical space, access to and trust in PPE, and a desire to deliver good patient care as additional factors to affect guidelines following (18). Secondly, high consequence infectious diseases have been shown to produce anxiety among HCWs which may hinder performance (19). Moreover, it is both intuitive and evidence based that performing medical tasks that require psychomotor skill would be more difficult when wearing PPE (1). Previous studies have assessed the impact of PPE on resuscitative efforts. Chen et al. found that wearing PPE in a resuscitation scenario significantly deteriorates the quality of chest compression and may thus deteriorate outcome and survival (20). Castle et al. concluded in their study that intubation and intravenous cannulation attempts are adversely affected by wearing PPE (21).

We found that the ED had significantly lower mean donning and doffing scores, potentially attributable to the suspected status of the patients, as opposed to the designated wards with COVID-19 confirmed positive patients. Moreover, fatigue from frequent PPE changes, high volume of patients with variable degrees of acuity and inappropriate staff-to-patient ratio combined with the negative impact of PPE on resuscitative efforts, as discussed before, may have a great influence on ED HCWs and explain our findings.

Our study highlights PPE donning and doffing errors. We believe there is a need for intensive practice and regular observations for appropriate PPE use, especially for ED teams. In the past, simulation and training methods were studied and significantly improved the trainee’s proficiency (11). For example, Abualenain et al. reported in their PPE simulation-based training, that the average score using checklist upon encounter suspected case of Ebola improved significantly after simulation training (22). Although beyond the scope of this current paper, yet of higher importance, is the work that has and should be done in order to better the adherence of HCWs to PPE protocols.

Limitations

This study had several limitations. Although we assume that pre-observation performance rates were much lower, compared to the post observation rates, we did not compare pre observation and post observation rates. Moreover, our hospital used only one style of long gown PPE and protocol (see additional file 1) during the time our study took place. Other types of PPE or different protocols may influence the error rate. A recent review published in the Cochrane database summarizes the differences between overalls, long gowns and aprons and their overall donning and doffing quality (23). Varbeek et al. found that although covering more of the body was shown to protect the HCW during care for affected patients, these PPEs were associated with less comfort, and increased difficulty in donning and doffing offering more opportunities for transmission.

Conclusions

PPE is a vital element used not only to combat pandemics but also in the daily dealing with common pathogens requiring contact precaution. Resources need to be extensively invested to assure implementation of PPE donning and doffing protocols in order to improve HCWs and patients’ protection. PPE type needs to be selected based on ease of care, comfort and training capabilities. Finally, a special focus needs to be invested in ED teams due to the special circumstances they confront with: high volume of patients with variable levels of acuity and unknown COVID-19 status.

Authors’ contributions

The author(s) read and approved the final manuscript.

References

  1. Adler MD, Krug S, Eiger C, Good GL, Kou M, Nash M, et al. Impact of Personal Protective Equipment on the Performance of Emergency Pediatric Tasks. Pediatr Emerg Care [Internet]. 2020 Feb 24. Volume Publish Ahead of Print - Issue Available from: https://doi.org/10.1097/PEC.0000000000002028.

  2. van Doremalen N, Bushmaker T, Morris DH, Holbrook MG, Gamble A, Williamson BN, et al. Aerosol and surface stability of SARS-CoV-2 as compared with SARS-CoV-1. N Engl J Med [Internet]. 2020;382(16):1564–7. Available from:. https://doi.org/10.1056/NEJMc2004973.

  3. Varia M, Wilson S, Sarwal S, McGeer A, Gournis E, Galanis E, et al. Investigation of a nosocomial outbreak of severe acute respiratory syndrome (SARS) in Toronto, Canada. CMAJ [Internet]. 2003;169(4):285–92 Available from: https://pubmed.ncbi.nlm.nih.gov/12925421/.

    Google Scholar 

  4. Islam eMS, Rahman KM, Sun Y, Qureshi MO, Abdi I, Chughtai AA, et al. Current knowledge of COVID-19 and infection prevention and control strategies in healthcare settings: A global analysis. Infect Control Hosp Epidemiol [Internet]. 2020;41(10):1–11. Available from: https://www.cambridge.org/core/product/identifier/S0899823X20002378/type/journal_article

  5. Kwon JH, Burnham C-AD, Reske KA, Liang SY, Hink T, Wallace MA, et al. Assessment of healthcare worker protocol deviations and self-contamination during personal protective equipment donning and doffing. Infect Control Hosp Epidemiol [Internet]. 2017;38(9):1077–83. Available from: https://www.cambridge.org/core/product/identifier/S0899823X17001210/type/journal_article. https://doi.org/10.1017/ice.2017.121.

  6. Remuzzi A, Remuzzi G. COVID-19 and Italy: what next? Lancet [Internet]. 2020 Apr;395(10231):1225–8. Available from: https://linkinghub.elsevier.com/retrieve/pii/S0140673620306279. https://doi.org/10.1016/S0140-6736(20)30627-9.

  7. Wang D, Hu B, Hu C, Zhu F, Liu X, Zhang J, et al. Clinical Characteristics of 138 Hospitalized Patients With 2019 Novel Coronavirus–Infected Pneumonia in Wuhan, China. JAMA [Internet]. 2020;323(11):1061 Available from: https://jamanetwork.com/journals/jama/fullarticle/2761044.

    Article  CAS  Google Scholar 

  8. Adams JG, Walls RM. Supporting the Health Care Workforce During the COVID-19 Global Epidemic. JAMA [Internet]. 2020;323(15):1439 Available from: https://jamanetwork.com/journals/jama/fullarticle/2763136.

    Article  CAS  Google Scholar 

  9. World Health Organization (WHO). Rational use of personal protective equipment for coronavirus disease 2019 (COVID-19) and considerations during severe shortages [Internet]. Who. 2020. p. 1–28. Available from: https://apps.who.int/iris/handle/10665/331695

  10. Centers for Disease Control and Prevention (CDC). Interim Infection Prevention and Control Recommendations for Patients with Suspected or Confirmed Coronavirus Disease 2019 (COVID-19) in healthcare settings [Internet]. CDC. 2, 2020:1–10 Available from: https://www.cdc.gov/coronavirus/2019-ncov/infection-control/control-recommendations.html.

  11. Casalino E, Astocondor E, Sanchez JC, Díaz-Santana DE, del Aguila C, Carrillo JP. Personal protective equipment for the Ebola virus disease: a comparison of 2 training programs. Am J Infect Control [Internet]. 2015;43(12):1281–7. Available from: https://linkinghub.elsevier.com/retrieve/pii/S0196655315007580. https://doi.org/10.1016/j.ajic.2015.07.007.

    Article  PubMed  Google Scholar 

  12. Verbeek JH, Rajamaki B, Ijaz S, Sauni R, Toomeye E, Blackwood B, et al. Personal protective equipment for preventing highly infectious diseases due to exposure to contaminated body fluids in healthcare staff. Verbeek JH, editor. Cochrane Database Syst Rev [Internet]. 2020; Available from: https://doi.org/10.1002/14651858.CD011621

  13. Kilmarx PH, Clarke KR, Dietz PM, Hamel MJ, Husain F, McFadden JD, et al. Ebola virus disease in health care workers--Sierra Leone, 2014. MMWR Morb Mortal Wkly Rep [Internet]. 2014;63(49):1168–71 Available from: http://www.ncbi.nlm.nih.gov/pubmed/25503921.

    Google Scholar 

  14. Lim SM, Cha WC, Chae MK, Jo IJ. Contamination during doffing of personal protective equipment by healthcare providers. Clin Exp Emerg Med [Internet] 2015;2(3):162–167. Available from: 10.15441/ceem.15.019

  15. Matanock A, Arwady MA, Ayscue P, Forrester JD, Gaddis B, Hunter JC, et al. Ebola virus disease cases among health care workers not working in Ebola treatment units--Liberia, June-August, 2014. MMWR Morb Mortal Wkly Rep [Internet]. 2014;63(46):1077–81 Available from: http://www.ncbi.nlm.nih.gov/pubmed/25412067.

    Google Scholar 

  16. Beam EL, Gibbs SG, Boulter KC, Beckerdite ME, Smith PW. A method for evaluating health care workers’ personal protective equipment technique. Am J Infect Control [Internet]. 2011;39(5):415–20. Available from: https://linkinghub.elsevier.com/retrieve/pii/S019665531000893X. https://doi.org/10.1016/j.ajic.2010.07.009.

    Article  Google Scholar 

  17. Zamora JE. Contamination: a comparison of 2 personal protective systems. Can Med Assoc J [Internet]. 2006;175(3):249–54. Available from:. https://doi.org/10.1503/cmaj.060094.

    Article  Google Scholar 

  18. Houghton C, Meskell P, Delaney H, Smalle M, Glenton C, Booth A, et al. Barriers and facilitators to healthcare workers’ adherence with infection prevention and control (IPC) guidelines for respiratory infectious diseases: a rapid qualitative evidence synthesis. Cochrane Database Syst Rev [Internet]. 2020 Apr 21; Available from: https://doi.org/10.1002/14651858.CD013582

  19. White MK, Vercruyssen M, Hodous TK. Work tolerance and subjective responses to wearing protective clothing and respirators during physical work. Ergonomics [Internet]. 1989;32(9):1111–23. Available from:. https://doi.org/10.1080/00140138908966878.

    Article  CAS  Google Scholar 

  20. Chen J, Lu K-Z, Yi B, Chen Y. Chest Compression With Personal Protective Equipment During Cardiopulmonary Resuscitation. Medicine (Baltimore) [Internet]. 2016;95(14):e3262 Available from: http://content.wkhealth.com/linkback/openurl?sid=WKPTLP:landingpage&an=00005792-201604050-00054.

    Article  Google Scholar 

  21. Castle N, Owen R, Hann M, Clark S, Reeves D, Gurney I. Impact of chemical, biological, radiation, and nuclear personal protective equipment on the performance of low- and high-dexterity airway and vascular access skills. Theatr Res Int. 2009;80(11):1290–5 Available from: https://linkinghub.elsevier.com/retrieve/pii/S0300957209004158.

    Google Scholar 

  22. Abualenain JT, Al-Alawi MM. Simulation-based training in Ebola personal protective equipment for healthcare workers: experience from king Abdulaziz University hospital in Saudi Arabia. J Infect Public Health [Internet]. 2018;11(6):796–800. Available from: https://linkinghub.elsevier.com/retrieve/pii/S1876034118300704. https://doi.org/10.1016/j.jiph.2018.05.002.

  23. Verbeek JH, Rajamaki B, Ijaz S, Sauni R, Toomey E, Blackwood B, Tikka C, Ruotsalainen JH, Kilinc Balci FS. Personal protective equipment for preventing highly infectious diseases due to exposure to contaminated body fluids in healthcare staff. Cochrane Database Syst Rev 2020, Issue 4. Art. No.: CD011621. DOI: https://doi.org/10.1002/14651858.CD011621.pub4. .

Download references

Funding

This research received no specific grant from any funding agency, commercial or not-for-profit sectors.

Author information

Authors and Affiliations

Authors

Corresponding author

Correspondence to Tali Capua.

Ethics declarations

Competing interests

None.

Additional information

Publisher’s Note

Springer Nature remains neutral with regard to jurisdictional claims in published maps and institutional affiliations.

Supplementary Information

Rights and permissions

Open Access This article is licensed under a Creative Commons Attribution 4.0 International License, which permits use, sharing, adaptation, distribution and reproduction in any medium or format, as long as you give appropriate credit to the original author(s) and the source, provide a link to the Creative Commons licence, and indicate if changes were made. The images or other third party material in this article are included in the article's Creative Commons licence, unless indicated otherwise in a credit line to the material. If material is not included in the article's Creative Commons licence and your intended use is not permitted by statutory regulation or exceeds the permitted use, you will need to obtain permission directly from the copyright holder. To view a copy of this licence, visit http://creativecommons.org/licenses/by/4.0/. The Creative Commons Public Domain Dedication waiver (http://creativecommons.org/publicdomain/zero/1.0/) applies to the data made available in this article, unless otherwise stated in a credit line to the data.

Reprints and permissions

About this article

Check for updates. Verify currency and authenticity via CrossMark

Cite this article

Lamhoot, T., Ben Shoshan, N., Eisenberg, H. et al. Emergency department impaired adherence to personal protective equipment donning and doffing protocols during the COVID-19 pandemic. Isr J Health Policy Res 10, 41 (2021). https://doi.org/10.1186/s13584-021-00477-7

Download citation

  • Received:

  • Accepted:

  • Published:

  • DOI: https://doi.org/10.1186/s13584-021-00477-7

Keywords